Red Car FIRE
#121
Under the Lift
Lifetime Rennlist
Member
Lifetime Rennlist
Member
#122
Addict
Rennlist Member
Rennlist Member
Join Date: Oct 2003
Location: Gone. On the Open Road
Posts: 16,511
Received 1,652 Likes
on
1,076 Posts
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
Nothing locates the injector in the manifold bore except the clip.
Without the clip, or with it not properly fastened, the fuel pressue will push the injector out of the rail.
#124
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
Yes it was me.
The the injector doesn't "bottom out" in the intake the hole where it is inserted is the the same size all the way through. Even with the rail bolted down, the injector can wiggle down enough to allow the top seal to come out. Having the clips in properly is absolutely critical, and I found out the hard way. My clip was upside down.
The only way to work on the injectors is remove the rail as a whole, and clip/unclip them all on the bench and reinstall all four together.
Here's a pic of mine.
The the injector doesn't "bottom out" in the intake the hole where it is inserted is the the same size all the way through. Even with the rail bolted down, the injector can wiggle down enough to allow the top seal to come out. Having the clips in properly is absolutely critical, and I found out the hard way. My clip was upside down.
The only way to work on the injectors is remove the rail as a whole, and clip/unclip them all on the bench and reinstall all four together.
Here's a pic of mine.
![](https://rennlist.com/forums/attachments/928-forum/973301d1442335903-engine-fire-img_20150915_123143_1067_800.jpg)
#125
Captain Obvious
Super User
Super User
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
What is the likelihood that when the injector got tapped "to wake it up" the injector got pushed out of the rail and the clip too?
#126
Former Sponsor
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
All of the skinny, lightweight Bosch injectors I tried (when the older style became difficult to obtain) had the groove for the clip in the improper location, allowing the injector to pop out of the rail.
I machined a correct groove in several sets of these injectors, before locating a source for the "proper" injector design.
Might be worth looking at....
I machined a correct groove in several sets of these injectors, before locating a source for the "proper" injector design.
Might be worth looking at....
#128
Rennlist Member
Thread Starter
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
The car is covered up and sitting in front of my house...The sunroof is open which I can manually close
but the drivers window is open, I concerned about hooking up the battery to get the window closed
Any suggestions?
but the drivers window is open, I concerned about hooking up the battery to get the window closed
Any suggestions?
#129
Former Sponsor
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
It turns out that the insurance adjuster that looked at the car and the underwriter have a different value system. So far they have offered 11k. The battle begins
I am thinking more and more and my family supports this as well as to keep it and fix it. I know it doesn't like me but maybe this exorcism helped. Success is going from failure to failure with enthusiasm.
I am thinking more and more and my family supports this as well as to keep it and fix it. I know it doesn't like me but maybe this exorcism helped. Success is going from failure to failure with enthusiasm.
The best oprion is to not allow the car to be "totalled" at all, but make the insurance company fix the car.
The offer of 11K is absurd. Keep in mind that an 86.5 just sold for 52K and that car wasn't ant nicer than this one (I worked extensively on both)...and didn't have 20K+ in "restoration" invoices.
The adjuster's job is to offer as low an amount as he possibly can....to reduce the company's loss!
Go back and tell him to find you a 86.5 in your condition for 11K and buy it for you to replace this one.
The story will quickly change!
#130
Addict
Lifetime Rennlist
Member
Lifetime Rennlist
Member
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
Also might help is several of you with 1985-86 cars put them up for sale on craigslist asking BIG money....costs you nothing BUT a bit of time just do not put in a phone # unless you really wish to sell
![Smilie](https://rennlist.com/forums/images/smilies/smile.gif)
#131
Addict
Rennlist Member
Rennlist Member
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
Drop the console side and power the window motor up at the switch is likely easiest. Or hook the battery up but disconnect the engine Harness from the ce and pull the fuel relay.
#132
Administrator - "Tyson"
Lifetime Rennlist
Member
Lifetime Rennlist
Member
![Default](https://rennlist.com/forums/images/icons/icon1.gif)
Just need some good photos, any one of us can post up one for sale.