For the Non Believers
#4
Addict
Rennlist Member
Rennlist Member
You da man !
#6
Rennlist Member
NICE - 252K more to go and I'll be there too.
Trending Topics
#14
Addict
Rennlist Member
Rennlist Member
Thread Starter
Here is a list I have compiled over the years for the repair work:
• All three front radiators (right front now twice)
• water pump
• coolant expansion tank (as a precaution with water pump)
• power steering pump/reservoir (for the annoying squeal)
• right front bearing, left rear bearing
• front diff (due to front bearing issue)
• clutch accumulator and slave cylinder (4 times now for the slave - one time lasted only 4 days and it failed - PCNA pulled all the parts on the shelves in the US as a result of this and a few others in the country with a similar issue)
• wiring harness repair (passenger side front most cylinder – harness to the coil pack chaffing issue)
• rear main seal (while engine was down for a wiring harness repair we pulled the tranny to inspect the bearings, clutch, pressure plate and flywheel)
• two bearings in the clutch assembly – one was bad, one was fine
• Decarbon the secondary air ports from the intakes to the exhaust
• Gas cap – the gasket finally went at 186,000+ miles
• Check valve and carbon canister on the vapor recovery system for the fuel tank
• normal services done on time
• brake pads (only on the 4th rear set and 5th front set - car has PCCB's and is tracked 6-10 days/year)
• oil changes every 5000 miles religiously – Mobil 1 0W-40
• tranny and diff fluids every 60,000 miles
• Baileys DV's
• GT-3 Cup front brake ducts
• Idler pulleys
• Belt (done a couple of times)
• Suspension will be replaced shortly (KW Clubsport)
• Carden shaft will be replaced (second time now) when the suspension is done
• All four half shafts will be replaced with the suspension
• Motorsport Sways and Tarett drops links will be replaced with the suspension
• Protomotive intercoolers going in when suspension is done
• Two rear heat shields will be replaced when the suspension is done
The car is on the original turbo's, original clutch and original engine still.
T2 continues to knock on wood....................
• All three front radiators (right front now twice)
• water pump
• coolant expansion tank (as a precaution with water pump)
• power steering pump/reservoir (for the annoying squeal)
• right front bearing, left rear bearing
• front diff (due to front bearing issue)
• clutch accumulator and slave cylinder (4 times now for the slave - one time lasted only 4 days and it failed - PCNA pulled all the parts on the shelves in the US as a result of this and a few others in the country with a similar issue)
• wiring harness repair (passenger side front most cylinder – harness to the coil pack chaffing issue)
• rear main seal (while engine was down for a wiring harness repair we pulled the tranny to inspect the bearings, clutch, pressure plate and flywheel)
• two bearings in the clutch assembly – one was bad, one was fine
• Decarbon the secondary air ports from the intakes to the exhaust
• Gas cap – the gasket finally went at 186,000+ miles
• Check valve and carbon canister on the vapor recovery system for the fuel tank
• normal services done on time
• brake pads (only on the 4th rear set and 5th front set - car has PCCB's and is tracked 6-10 days/year)
• oil changes every 5000 miles religiously – Mobil 1 0W-40
• tranny and diff fluids every 60,000 miles
• Baileys DV's
• GT-3 Cup front brake ducts
• Idler pulleys
• Belt (done a couple of times)
• Suspension will be replaced shortly (KW Clubsport)
• Carden shaft will be replaced (second time now) when the suspension is done
• All four half shafts will be replaced with the suspension
• Motorsport Sways and Tarett drops links will be replaced with the suspension
• Protomotive intercoolers going in when suspension is done
• Two rear heat shields will be replaced when the suspension is done
The car is on the original turbo's, original clutch and original engine still.
T2 continues to knock on wood....................
#15
Three Wheelin'
T2 did I read somewhere that you are from New England and you are driving your car in winter? Salt, slush, rain + you are tracking your car! Amazing, may be that is one of the aspect of this kind of car it should not be a garage queen, but driven daily!