Accurate weight table - Rennlist - Porsche Discussion Forums

Notices
964 Forum
Sponsored By:
Sponsored By:

Accurate weight table

 
Old 01-02-2006, 11:04 AM
  #1  
AVoyvoda
User
Thread Starter
 
Join Date: Nov 2005
Location: London
Posts: 310
Default Accurate weight table

We are all interested in weight loss but are missing a complete reference table showing the various components’ weights. There’s plenty of information on Rennlist but it’s all over the place and often wrong.
I've made a start putting it all together: weight in lbs (2.240 lbs to 1 kg) manual narrow C2 Coupe, unless otherwise stated.
Corrections/additions are very welcome. A complete and accurate weight guide should be of great help to all members of this forum.

Curb weight euro (DIN) 3,031 (including all fluids, full gas tank but without any options such as a/c, radio, sunroof etc.)

Hood 42.0
Hood hinges, both 3.7
Front hood struts, each 1.0
Rear deck struts, each 1.0
Rear deck lid 10.0
Moveable rear wing 8.0
Fully motorized rear lid 24.0

Door, each 81.0
RS Door, each 50
Stock door shell, each 38
US Collision bar in door
Door hinges, 4 pairs 1.5
Elect window mechanism 3.0
Flag Mirrors, both 6.7
Teardrop Mirrors, both 4.5
Rear wiper complete 4.5

Sunroof 44.0
Window Glass
Rear Glass
Front seat (comfort, normal) each 52.5
Bucket seat (RS) including mounts, each 30.5
Rear seats, both 15.4
Rear seatbelts, both 4

US 5 mph bumper supports F/R
US rear bumper beam 16.0
RS euro rear bumper beam 11.5
US front bumper beam 13.25
US rear bumper 5.0
US front Bumper
Bumperettes, both 2
Front Fogs, both 4.0
Third brake light 4.0

Cup 1 Wheel set 7, 8 x 17 41.4
Front calliper + pad 12.7
Front rotor 17.0
Rear brake 29.7
Wheel bolts (lug nuts x 20) 4.2
Power steering 22.0

G50/20 gearbox (manual) with LSD 156
Stock con-rods, each 669 – 678 grams
Pistons, each
Crank
Crank pulley and dampener 1,161 grams
Engine casing

Complete exhaust system with CAT 96.0
Primary muffler 22.4
Secondary muffler 22.8
Engine under tray 14.0
Dual mass Flywheel 30.5
Clutch

Under floor soundproofing + carpet 69.4
Carpet + pad 22
Engine insulation 10.0
Trunk carpet + liner 5.6
Front windshield washer tank with pump 12.0

Under seal
Wheel well plastic protectors

Battery 75Ah 46
Aircon + coolant + hoses 47.0
Airbags (driver + pas) 13.0
Tunnel under tray/stiffener 5.0
Heater/blower 6.5
Spare tire + air pump 34.6
AVoyvoda is offline  
Old 01-02-2006, 08:24 PM
  #2  
ttAmerica RoadsterAWD
User
 
ttAmerica RoadsterAWD's Avatar
 
Join Date: Jan 2005
Location: Eagle, ID
Posts: 1,375
Default

Wow! thank you. Great reference point.

Jaime
ttAmerica RoadsterAWD is offline  
Old 01-03-2006, 01:01 AM
  #3  
forklift
Addict
Rennlist Member
 
forklift's Avatar
 
Join Date: Nov 2003
Location: VA
Posts: 2,112
Default

Great post!
forklift is offline  
Old 06-03-2006, 01:55 AM
  #4  
Cupcar#12
Addict
Rennlist Member

 
Cupcar#12's Avatar
 
Join Date: Apr 2002
Location: Apex, NC
Posts: 2,424
Default

let's keep this going - i'll buy a scale since my car is mostly apart right now
Cupcar#12 is offline  
Old 06-03-2006, 03:15 AM
  #5  
LA964RS
Addict
Rennlist Member
 
LA964RS's Avatar
 
Join Date: Sep 2004
Posts: 2,300
Default

This is excellent....anyone car to add anything?
LA964RS is offline  
Old 06-03-2006, 05:56 AM
  #6  
AVoyvoda
User
Thread Starter
 
Join Date: Nov 2005
Location: London
Posts: 310
Default Update

Since you are asking, here's the latest... Weight in lbs unless shown differently.

Bonnet 42.0
Hood hinges, both 3.7
Front hood struts, each 1.0
Rear deck struts, each 1.0
Rear deck lid w/o wing 10.0
Moveable rear wing 8.0
Fully motorized rear lid 24.0

4WD Tub (tub only, NO doors, hood, fenders, undercoat, paint, seam sealer etc.) 424.0
Tub undercoating + Paint + seam sealer 86.0
Doors, each 81.0
RS Doors, each 50.0
Stock door shell, each 38.0
Skin, each 18.0
Glass 10.0
US Collision bar in door
Door hinges, 4 pairs 1.5
Elect window mechanism + motor 22.0
Electric window motors (both) 3.0
Flag Mirrors, both 6.7
Teardrop Mirrors, both 4.5
Rear wiper and motor, complete 4.5
Windshield
Rear Glass
Sunroof 44.0

Door panels with pockets, both 17.0
RS Door panels, both 6.5
Rear shelf 24.0
RS/Cab rear 'luggage dump' 25.0
Airbag steering wheel 9.0
Front seat (comfort, normal) each 52.5
Bucket seat (RS) including mounts, each 30.5
Recaro Pole Position including mounts, each 28.0
Cobra Misano R 23.0
Rear seats, both 15.4
Rear seatbelts, both 4.0
Under floor soundproofing + carpet 69.4
Carpet + pad 22.0

US 5 mph bumper supports F/R (four) 12.0
US rear bumper beam 16.0
RS euro rear bumper beam 11.5
US front bumper beam 13.3
US rear bumper 5.0
US front Bumper
Bumperettes, both 2.0
Front Fogs, both 4.0
Third brake light 4.0

Cup 1 OEM Wheel set 7, 8 x 17 100.4
Bilstein PSS9 set approx 65.0
Wheel well plastic protectors

964 Front calliper + pad 12.7
964 Front rotor 17.0
Rear brake 29.7
Front Rotor Protective plates x 2
RS Rotor Protective plates x 2
Uprights x 2
Wheel bolts (lug nuts x 20) 4.2
Power steering 22.0

G50/20 gearbox (manual) with LSD 156.0
Tiptronic gearbox 222.0
Stock con-rods, each 669 - 678 grams
Pistons, each
Crank
Crank pulley and dampener 1,161 grams
Engine casing
Alternator Bosch 115 amp 6+

Basic exhaust 30.0
Primary muffler 23.5
Secondary muffler 23.3
Catalytic Converter and shielding 16.0
Total 92.8
Metal tube for pass compartment heat 4.0
Engine under tray 14.0
Dual mass Flywheel 30.5
LW flywheel 12.3
Clutch

Trunk carpet + liner 5.6
Engine insulation 10.0
Front windshield washer tank with pump 12.0

Battery 75Ah 46.0
Wiring harness, w/o fuse panel 55.0
Aircon + coolant + hoses 47.0
Airbags, harness, sensors (driver + pas) 13.5
Tunnel under tray/stiffener 5.0
Heater/blower 6.5
Spare tire + air pump 34.6

Full tank of gas (US tank 77 liters, 20 gallons) 116.0
Full tank of gas (Grosse tank, 92 litre) 138.6
Engine oil (15qts) 25.0
Transmission oil 8.0
Aircon fluid
AVoyvoda is offline  
Old 06-03-2006, 04:54 PM
  #7  
jeff522
User
 
jeff522's Avatar
 
Join Date: Mar 2006
Location: Joplin, Mo
Posts: 345
Default

God I feel so fat
or
Dose this wing make my deck lid look fat
or
I sure got moms wide body wheel wells
or
He says it dosen't matter how much I weigh,yea right,did you se how he looked at that Cup Car over there.
or
She 's had so much carbon fiber and fiberglass done I bet not one bit of her body is factory.If she gets hit out there he's in for quite a surprize

A little humer very little....but I dought I'm the only guy car is the other women.
jeff522 is offline  
Old 06-05-2006, 02:34 PM
  #8  
frankvan
User
 
frankvan's Avatar
 
Join Date: Jan 2005
Location: St. Albert, Alberta, Canada
Posts: 696
Default curiosity...

how much does the engine weigh? (with or without exhaust?)

I know this info is out there (i've seen it) but haven't been able to find it again.
frankvan is offline  
Old 06-05-2006, 06:19 PM
  #9  
agentpennypacker
Addict
Rennlist Member
 
agentpennypacker's Avatar
 
Join Date: Feb 2004
Location: Mighty Kansas City
Posts: 616
Default

manual vs power steering rack (and pump)? I'm actually swapping mine out fairly soon. If we don't have it by then, I can tell you from my home scale.
agentpennypacker is offline  
Old 06-06-2006, 06:43 PM
  #10  
springer3
Addict
Rennlist Member

 
springer3's Avatar
 
Join Date: Jul 2003
Location: Atlanta
Posts: 2,551
Default

Originally Posted by AVoyvoda
....(2.240 lbs to 1 kg)....
Great post. In case somebody tries to convert, it is 2.2046 lbs to 1 kg.
springer3 is offline  
Old 12-09-2006, 07:57 PM
  #11  
ttAmerica RoadsterAWD
User
 
ttAmerica RoadsterAWD's Avatar
 
Join Date: Jan 2005
Location: Eagle, ID
Posts: 1,375
Default

Back from the Dead....

Front windshield (glass+rubber seal+rearveiw mirror+ antennae wire+any grime) Weighed in at 22 lbs. Used bathroom scale, preloaded with 10lbs, then 20 lbs (from a weight set) for accuracy, then place windshield on and subtracted the 10 lbs, then subtracted 20lbs, then weighed sheild without preload...all indicate about 22 lbs.

Jaime
ttAmerica RoadsterAWD is offline  
Old 12-10-2006, 04:01 PM
  #12  
TR6
Super User
 
TR6's Avatar
 
Join Date: Jun 2006
Location: Dallas/FortWorth Texas
Posts: 3,438
Default

I'd be interested in knowing:

1) Net effect of sunroof vs non-sunroof. The sunroof weight is listed above, but a car without a sunroof has some weight in steel that fills that hole. At least a few pounds...
2) How much does the spare tire weigh alone (sans air pump)?
3) Stereo speakers and in-dash head unit?
4) US spec RS America seats?
5) Roll bar/cage weight?
TR6 is offline  
Old 12-10-2006, 04:06 PM
  #13  
forklift
Addict
Rennlist Member
 
forklift's Avatar
 
Join Date: Nov 2003
Location: VA
Posts: 2,112
Default

Hi Greg,

I am 99% sure that 44 lbs is the net savings, not the weight of the panel.

I think the spare tire weighs 33 lbs IIRC

I think a full cage is around 150 lbs depending on steel vs. cro-mo, thickness of tubing and configuration. I think my roll bar is around 70 lbs, so when I put in a cage I am also going to swap roofs for a net gain of around 30 lbs.

Notice on all of this I said, I think, but all should should be pretty close.
forklift is offline  
Old 12-28-2006, 09:26 AM
  #14  
maximu5
User
 
maximu5's Avatar
 
Join Date: Oct 2006
Location: Brussels, Belgium, 1 hour West of Spa, 2 hours West of the Ring ;-)
Posts: 89
Default

anybody know what the front wings each weigh ?
maximu5 is offline  
Old 12-29-2006, 02:46 AM
  #15  
AVoyvoda
User
Thread Starter
 
Join Date: Nov 2005
Location: London
Posts: 310
Default

Front wings: Steel, approx 17lbs each, 4.2 lbs in carbon.

As to engine weight (previous question)
Engine complete 964 RS 3.6 na 498
Engine complete 964 3.6 na 525
Engine complete 964 3.6 turbo 608
Engine complete 993 3.6 na 511
Engine complete 993 3.6 turbo 591
AVoyvoda is offline  

Thread Tools
Search this Thread
Quick Reply: Accurate weight table


Contact Us About Us Advertising Cookie Policy Privacy Statement Terms of Service

© 2019 MH Sub I, LLC dba Internet Brands

We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.
 
  • Ask a Question
    Get answers from community experts
Question Title:
Description:
Your question will be posted in: