BSL

When swapping out a heater mix flap in the passenger side footwell, I managed to tear the hose that runs from the flap up to the dash . I have looked at the PET diagrams, but am unable to find the chart for that section (maybe I keep skipping over it?). Does anyone know what this part number is, or even better, have removed it and are willing to sell it?

Thanks!

jhg41977

I have some, it comes in 2 meter lengths

jhg41977

oops, maybe not, didnt realize this was the upfront flap. I have the 72/73mm orange tubing

BSL

Yes, this is different than the orange tubing (I still have a bit of that as well). This is a paper-like outside with foil on the inside.

Renaud Bizet

Sorry not to hijack the thread. Where did you source the "orange tubing" that goes on the heater flaps at the bottom of the engine?
During last oil change when I took it out to access the engine oil filter I noticed that it is splitting badly.

Thanks !!!

bjornebo

The heater hose that BSL is looking for is shown in Illustration 813-00 on page 386 of the PET- item 12 (p/n 993 572 528 01).

Eurotrio

I too noticed small tears on the orange short sections of hose....appx 2" long. Crazy, but dealer sells it in 6 feet sections about $200.

I just received some hose sections from Forge to try out. Will report later how it works out.

Renaud Bizet

Cool, sure please report back I am interested to see what I could use. It has to be quite pliable and able to resist the heat too.

Thanks !!!

BSL

Ah, thanks George! I saw that diagram, but wasn't associating that run going into the cabin and back to the heat exchanger.